LBVR/A 12-24VDC Broyce Control

Type: LBVR/A Battery Voltage Relay Terminal *NEW* 17.5mm DIN rail housing Protection Microprocessor based to IP20 Suited to 12V and 24V batteries Monitors own supply and detects and Under voltage condition Adjustment for Under voltage trip level (9 28V) Adjustment for Time delay (from an Under voltage condition) 1 x SPDT relay output 8A Green LED indication for supply status Red LED indication for relay status Dims: to DIN 43880 W. 17.5mm FFUUNNCCTTIIOONN DDIIAAGGRRAAMM TTEECCHHNNIICCAALL SSPPEECCIIFFIICCAATTIIOONN Supply/monitoring voltage U (A1, A2): 12 24V DC Supply A1, A2 Supply variation: 75 125% U Power consumption (max.): 3W % Hyst. Monitoring mode: Under voltage Monitored Voltage Trip level: 9 28V DC Trip Level Hysteresis: 5% of trip level (factory set) Setting accuracy: 10% Repeat accuracy: 0.5% at constant conditions Output Response time: 100mS 18 Time delay (t): 0 30 Sec. ( 5%) 15 Note: actual delay (t) = adjustable delay + response time 16 Power on delay (Td): 1 sec. (worst case = Td x 2) BVRA0215 t Power on indication: Green LED Relay status indication: Red LED Ambient temp: -20 to +60C LED operation: LED Off LED On LED Flashing Relative humidity: +95% Output (15, 16, 18): SPDT relay Output rating: AC1 250V 8A (2000VA) Installation work must be carried IINNSSTTAALLLLAATTIIOONN AANNDD SSEETTTTIINNGG AC15 250V 5A (no), 3A (nc) out by qualified personnel. DC1 25V 8A (200W) BEFORE INSTALLATION, ISOLATE THE SUPPLY. Electrical life: 150,000 ops at rated load Connect the unit as required taking note of the polarity of the connections. Terminal A1 is the positive Dielectric voltage: 2kV AC (rms) IEC 60947-1 connection and A2 the negative. Rated impulse withstand voltage: 4kV (1.2/50S) IEC 60664 Housing: Orange flame retardant UL94 Setting the unit. Weight: 70g Set the Under voltage Trip Level (V) adjustment to the voltage required. Mounting option: On to 35mm symmetric DIN rail to BS EN 60715 or direct surface mounting via 2 x M3.5 or 4BA screws Set the Delay (t) to minimum. using the black clips provided on the rear of the unit. 2 Terminal conductor size 2 x 2.5mm solid or stranded Applying power. Approvals: Apply power and the green Power supply and red Relay LEDs will illuminate, the relay will Conforms to IEC. CE, and RoHS Compliant. energise and contacts 15 and 18 will close. Refer to the troubleshooting table if the unit fails to operate EMC: Immunity/Emissions to EN 61000-6 correctly. If the supply voltage drops below the trip level setting, the green LED will start to flash. The relay will then de-energise (contacts 15 and 18 open) after the delay period t and the red LED will extinguish. The green LED will then remain permanently lit. When the voltage increases above the trip level + hysteresis, then relay will re-energise and red LED illuminate. Troubleshooting. The table below shows the status of the unit during a fault condition. Supply fault Green LED Red LED Relay No supply Off Off De-energised Under voltage condition (during timing) Flashing On Energised for set delay (t) Under voltage condition (after timing) On Off De-energised CONNECTION DIAGRAM CONNECTION DIAGRAM SSEETTTTIINNGG DDEETTAAIILLSS DDIIMMEENNSSIIOONNSS Supply / Monitored 89 (exc. clips) 1. Power supply status Voltage 67.5 +ve -ve (Green) LED 45 2. Relay output status A1 (Red) LED 3. Delay adjustment 15 4. Under trip level adjustment Insert screwdriver to release clips 15 R 16 18 Withdraw clips 16 18 fully when surface mounting A2 92 (+/- 1mm) all dimensions in mm. Broyce Control Ltd., Pool Street, Wolverhampton, West Midlands WV2 4HN. England LBVR A-1-A XXXXX Tel: +44 (0) 1902 773746 Fax: +44 (0) 1902 420639 Email: sales broycecontrol.com Web: www.broycecontrol.com The Information provided in this literature is believed to be accurate (subject to change without prior notice) however, use of such information shall be entirely at the users own risk. 29 49.5 66.5X-ON Electronics Largest Supplier of Electrical and Electronic Components Click to view similar products for Industrial Relays category: Click to view products by Broyce Control manufacturer: Other Similar products are found below : 6-1618400-7 686-117111 686-120111 EV250-4A-02 EV250-6A-01 FCA-125-CX8 FCA-410-138 8-1618393-1 GCA32A208VAC60HZ GCA32A220VAC50/60HZ GCA32A230VAC50/60HZ GCA32A240VAC50/60HZ GCA32A48VAC60HZ GCA63A120VAC50/60HZ GCA63A208VAC60HZ GCA63A220VAC60HZ GCA63A230VAC50/60HZ GCA63A240VAC50/60HZ GCA63A277VAC60HZ GCA63A48VAC60HZ GCA63A500VAC50/60HZ GCA63A600VAC60HZ GCA800A200VACDC GCA95A110VAC50/60HZ GCA95A120VAC50/60HZ GCA95A12VDC GCA95A240VAC50/60HZ GCA95A24VAC50/60HZ GCA95A48VAC60HZ ACC530U20 ACC730U30 1395832-1 RM699BV-3011-85-1005 RMIA210230AC RMIA45024AC 1423675-8 B07B032AC1-0329 B329 1617807-1 N417 P25-E5019-1 P30C42A12D1-120 2-1618398-1 PBO-18A1218 2307497 RPYA00324LT RPYA003A120LT KR-4539-1 RT334012WG S160156115