HRPG-600-24 Mean Well

600W Single Output with PFC Function HRPG-600 series Users Manual ) % & ( & ) * + & + + , +- + . +/ , +- + * &0 ( 1 , - & 2 , 3 4(% 5- 67 89 % 5 : 7 589 6 9 7 ( 2 Bauart gepruft Sicherheit egelma ge od os be wac g www.tuv.com ID 2000000000 UL62368-1 BS EN/EN62368-1 TPTC004 IEC62368-1 SPECIFICATION MODEL HRPG-600-3.3 HRPG-600-5 HRPG-600-7.5 HRPG-600-12 HRPG-600-15 HRPG-600-24 HRPG-600-36 HRPG-600-48 DC VOLTAGE 3.3V 5V 7.5V 12V 15V 24V 36V 48V RATED CURRENT 120A 120A 80A 53A 43A 27A 17.5A 13A CURRENT RANGE 0 ~ 120A 0 ~ 120A 0 ~ 80A 0 ~ 53A 0 ~ 43A 0 ~ 27A 0 ~ 17.5A 0 ~ 13A RATED POWER 396W 600W 600W 636W 645W 648W 630W 624W RIPPLE & NOISE (max.) Note.2 120mVp-p 150mVp-p 150mVp-p 150mVp-p 150mVp-p 150mVp-p 200mVp-p 240mVp-p OUTPUT VOLTAGE ADJ. RANGE 2.8 ~ 3.8V 4.3 ~ 5.8V 6.8 ~ 9V 10.2 ~ 13.8V 13.5 ~ 18V 21.6 ~ 28.8V 28.8 ~ 39.6V 40.8 ~ 55.2V VOLTAGE TOLERANCE Note.3 2.0% 2.0% 2.0% 1.0% 1.0% 1.0% 1.0% 1.0% LINE REGULATION 0.5% 0.5% 0.5% 0.3% 0.3% 0.2% 0.2% 0.2% LOAD REGULATION 1.0% 1.0% 1.0% 0.5% 0.5% 0.5% 0.5% 0.5% SETUP, RISE TIME 1000ms, 50ms/230VAC 2500ms, 50ms/115VAC at full load HOLD UP TIME (Typ.) 16ms/230VAC 16ms/115VAC at full load VOLTAGE RANGE Note.4 85 ~ 264VAC 120 ~ 370VDC FREQUENCY RANGE 47 ~ 63Hz POWER FACTOR (Typ.) PF>0.93/230VAC PF>0.99/115VAC at full load INPUT EFFICIENCY (Typ.) 78.5% 82% 86% 88% 88% 88% 89% 89% AC CURRENT (Typ.) 7.6A/115VAC 3.6A/230VAC INRUSH CURRENT (Typ.) 35A/115VAC 70A/230VAC LEAKAGE CURRENT <1.2mA / 240VAC 105 ~ 135% rated output power OVERLOAD Protection type : Constant current limiting, recovers automatically after fault condition is removed 6 ~ 7V 9.4 ~ 10.9V 14.4 ~ 16.8V 18.8 ~ 21.8V 30 ~ 34.8V 41.4 ~ 48.6V 57.6 ~ 67.2V PROTECTION 3.96 ~ 4.62V OVER VOLTAGE Protection type : Shut down o/p voltage, re-power on to recover Shut down o/p voltage, recovers automatically after temperature goes down OVER TEMPERATURE 5VSB : 5V 0.3A tolerance5%, ripple : 50mVp-p(max.) 5V STANDBY PSU turn on : 3.3 ~ 5.6V PSU turn off : 0 ~ 1V DC OK SIGNAL FUNCTION RC+ / RC-: 4 ~ 10V or open = power on 0 ~ 0.8V or short = power off REMOTE CONTROL Load 3515% or RTH2 50 Fan on FAN CONTROL (Typ.) -40 ~ +70 (Refer toDerating Curv) WORKING TEMP. 20 ~ 90% RH non-condensing WORKING HUMIDITY -40 ~ +85, 10 ~ 95% RH non-condensing ENVIRONMENT STORAGE TEMP., HUMIDITY TEMP. COEFFICIENT 0.03%/ (0 ~ 50) VIBRATION 10 ~ 500Hz, 5G 10min./1cycle, 60min. each along X, Y, Z axes SAFETY STANDARDS UL62368-1, TUV BS EN/EN62368-1, EAC TP TC 004 approved WITHSTAND VOLTAGE I/P-O/P:3KVAC I/P-FG:2KVAC O/P-FG:0.5KVAC SAFETY & ISOLATION RESISTANCE I/P-O/P, I/P-FG, O/P-FG:100M Ohms / 500VDC / 25/ 70% RH EMC (Note 7) EMC EMISSION Compliance to BS EN/EN55032 (CISPR32) Class B, BS EN/EN61000-3-2,-3, EAC TP TC 020 EMC IMMUNITY Compliance to BS EN/EN61000-4-2,3,4,5,6,8,11, BS EN/EN55024, BS EN/EN61000-6-2, heavy industry level, criteria A, EAC TP TC 020 147.7K hrs min. MIL-HDBK-217F (25) MTBF OTHERS DIMENSION 218*105*63.5mm (L*W*H) PACKING 1.58Kg 8pcs/13.6Kg/1.34CUFT , -+< , & , & 8 & & & 8( ,0 , NOTE 8 = > , & 8 0 &2 & 0 8A 2 & 2 , & 2 > 94 < ) & & & 9 . , 0 & & & 2 B & , & ( C , , & & < +- + 2 , & , 6 - & 2 , 3 4(% 2 = : > = 5 - 97 D 4 < 2 & & , 2 2 0 & E , F 0 G & 0 , 6 ,,H 6 ,, , 2 ,, B < E , , 0 , & , F & & 2 , F IF J , 2 K 5 0 600W Single Output with PFC Function HRPG-600 series MechanicalMechanical Specification Specification Case No. 977A Unit:mm 152.4 32.8 O/P 1 4-M4 L=6 2 Air flow 3 direction 4 I/P 5 6 1 2 1 9 3 2 10 218 152.4 32.8 8-M4 L=4 (Both Sides) 18max. 12max. AC Input Terminal Pin No. DC Output Terminal Pin No. Connector Pin No. Assignment(CN100) : HRS DF11-10DP-2DS or equivalent Assignment Assignment Pin No. Assignment Pin No. Assignment Mating Housing Terminal 1 AUXG 6,8 GND Pin No. Assignment Pin No. Assignment 2 AUX 7 DC-OK 1 AC/L 1~3 -V HRS DF11-10DS HRS DF11-**SC 3 RC+ 9 +S 2 AC/N 4~6 +V or equivalent or equivalent 4 RC- -S 3 FG 10 5 CS Block Diagram PWM fosc : 70KHz RECTIFIERS AUX AUX & POWER AUXG FILTER +S ACTIVE RECTIFIERS RECTIFIERS EMI +V INRUSH POWER & I/P & FILTER CURRENT SWITCHING -V PFC FILTER LIMITING -S DETECTION O.L.P. O.T.P. CIRCUIT DC OK FG O.T.P. CURRENT PWM PFC O.V.P. CS SHARING CONTROL CONTROL RC+ REMOTE CONTROL RC- Derating Curve Output Derating VS Input Voltage 100 125 90 100 80 80 70 60 50 The 5V standby must be connected 50 with a minimum load of 0.03A. 20 40 -40 -20 10 20 30 40 50 60 70 (HORIZONTAL) 85 100 125 135 155 264 AMBIENT TEMPERATURE () INPUT VOLTAGE (V) 60Hz File Name:HRPG-600-SPEC 2021-09-15 LOAD (%) 10 8.2 63.5 20.75 LOAD(%) 9.2 11 12.5 38.3 63.5 CN100 LED (Vo ADJ.)SVR1 105