Resistors Low Value Current Sense Surface Mount Chip Resistors LRCS / LVC Series 0402, 0603 and 0805 sizes (larger sizes refer to our LRF Series) Resistance R020 (20m) to 1R0 (1000m) Designed for current sensing in power electronic systems RoHS compliant AllAll partsparts araree Pb-Pb-frfreeee andand ccomplyomply withwith EUEU DirDirectivectivee 2011/65/EU2011/65/EU amendedamended bbyy (EU)(EU) 2015/8632015/863 (R(RoHS3)oHS3) Electrical Data LRCS/LVC0402 LRCS/LVC0603 LRCS/LVC0805 0.125: R02 to <R10 Power rating 70C watts 0.063 0.1 0.25: R10 to 1R0 Resistance Range ohms R05 to 1R0 R02 to 1R0 R02 to 1R0 Isolation voltage volts 50V 100V 200V 600: R02 - R05 600: R02 - R05 400: R05 - R10 400: R051 - R10 400: R051 - R10 TCR ppm/C 300: R101 - R50 300: R101 - R50 300: R101 - R50 200: R501 - 1R0 200: R501 - 1R0 200: R501 - 1R0 Resistance tolerance % 1(F), 5(J) Standard values E24 preferred Ambient temperature range C -55 to +155 Physical Data Dimensions (mm) & weight (mg) L W L W T C A Weight D E F C LRCS/LVC 1 0.5 0.32 0.25 0.2 0.7 0.65 0.65 0.9 0402 0.05 0.05 0.10 0.10 0.10 T LRCS/LVC 1.6 0.8 0.45 0.3 0.3 A 2.0 1 0.9 1.6 E 0603 0.10 0.10 0.10 0.20 0.20 F LRCS/LVC 2 1.25 0.55 0.3 0.4 D 5.3 1.4 0.95 2 0805 0.15 0.15 0.10 0.20 0.25 Construction A resistor element is applied to an alumina substrate. The product is adjusted to the value and protected. Marking is applied to 0603 and 0805 sizes. A wraparound conductor is applied to join the top and bottom sides. The terminations are electroplated with a Ni barrier layer prior to plating with a Sn finish. Solvent Resistance The body protection and marking are resistant to all normal industrial solvents suitable for printed circuits. Flammability The resistor will not burn or emit incandescent particles under any condition of applied temperature or overload. Solderability 95% min coverage (MIL-STD 202F / 208H, 235C 2 secs) General Note BI Technologies IRC Welwyn TT Electronics reserves the right to make changes in product specification without notice or liability. All information is subject to TT Electronics own data and is considered accurate at time of going to print. www.ttelectronics.com/resistors TT Electronics plc 07.18 R027Low Value Current Sense Surface Mount Chip Resistors LRCS / LVC Series Marking The LRCS0402 is not marked, the LRCS0603 is marked with 3 digits and LRCS0805 with 4 digits. e. g. 100m is marked as R10 (3digit) and R100 (4digit) and 35m is marked as 035 (3digit) or R035 (4digit) Performance Data Maximum Load at rated power (1000hrs cyclic load at 70C) R% 1% + 0.05 De-rating from rated power at 70C) See Graph 0.5% + 0.05 Short term overload (6.25 x rated power for 5s) R% 1% + 0.05(0.25W LRCS0805 rating) Dry heat (96Hrs, no load, +155C) R% 0.5% + 0.05 Temperature rapid change (-55 / +150C, 100 cycles) R% 0.5% + 0.05 Damp heat steady state R% 0.5% + 0.05 Resistance to solder heat (260C for 10s) R% 0.5% + 0.05 Low Temperature Operation R% 0.5% + 0.05 Insulation Resistance (100V, 60s) >1000M Power de-rating graph Packaging The standard packing for LRCS parts is on 8mm wide paper tape wound on 178mm diameter reels. Ordering Procedure This product has two valid part numbers: European (Welwyn) Part Number: LRCS0603-R027FT5 (0603, 27 milliohms 1%, Pb-free) L R C S 0 6 0 3 - R 0 2 7 F T 5 1 2 3 4 5 1 2 3 4 5 Type Size Value Tolerance Packing LRCS 0402 E24 = 3/4 characters F = 1% Tape & reel R = ohms 0603 J = 5% T10 0402 10,000/reel 0805 T5 0603, 0805 5000/reel USA (IRC) Part Number: LVC-LVC0603LF-R027-F (0603, 27 milliohms 1%, Pb-free) L V C - L V C 0 6 0 3 L F - R 0 2 7 - F 1 2 3 4 5 6 1 2 3 4 5 6 Packing Family Model Size Termination Value Tolerance LVC LVC 0402 LF = Pb-free F = 1% Tape & reel E24 = 3/4 characters 0603 R = ohms J = 5% 04021 210,000/reel 0805 0603, 0805 5000/reel General Note BI Technologies IRC Welwyn TT Electronics reserves the right to make changes in product specification without notice or liability. All information is subject to TT Electronics own data and is considered accurate at time of going to print. www.ttelectronics.com/resistors TT Electronics plc 07.18